Furnace Ignition and Pilot Light Repair in Ray, OH Near Me

Thermostat won't turn the furnace on? Here is what is usually behind it. Blank screen: swap the batteries. If it stays dark, the thermostat has probably lost its 24-volt supply, often from a blown low-voltage fuse on the furnace control board. Screen lit, no heat: confirm it is set to heat and no schedule or hold is overriding it. Make sure the furnace door is seated, since its safety switch cuts power when loose. Look for a tripped condensate float switch too. Stop and get a professional if a replacement fuse blows again. That fuse is a symptom of a short in the thermostat wiring, not a part to keep swapping. If you smell burning or see scorched wire, shut the furnace off at the breaker now. Pre-1990 Ray, OH homes often lack a common wire, which is why many smart thermostat installs fail. Pro HVAC is a referral service connecting Ohio homeowners with local HVAC pros. Call (321) 463-9811.

A weak thermocouple or drafts around the burner compartment usually cause the pilot to extinguish. First, ensure the furnace door is fully closed and the area around the unit is free of strong air currents. If the pilot still will not stay lit after relighting per the label instructions, turn the gas valve off and do not attempt further adjustments.

A burning smell on first startup in fall is often dust burning off the heat exchanger and may clear after a few hours. Persistent or strong odors can indicate overheating or electrical issues. Turn the thermostat down, switch power off at the breaker, and call (321) 463-9811. Do not keep running the unit in Ray, OH winter conditions if the smell returns.

A sealed air conditioning system does not use refrigerant up, so if the charge is low there is a leak somewhere. Cooling that weakens season after season, ice on the line set, or a hissing sound near the indoor unit all point to a leak rather than normal top-up. Adding refrigerant without locating the leak means paying again next season, and running low charge makes the compressor run hot. Ask for the leak to be found and quoted before agreeing to a recharge in Ray, OH.

Yes, and it is the most common cause of faults that look like equipment failure. A restricted filter makes a furnace overheat and shut down on its limit switch, freezes an air conditioning evaporator coil solid, and makes the blower motor draw high current until it fails early. Two things matter more than brand: the filter must fit its slot tightly, because a loose filter lets air bypass it completely, and a very high MERV rating in a system not designed for it restricts airflow enough to cause the same overheating it was meant to prevent. A filter that darkens within weeks in Ray, OH usually means duct leakage is pulling in unfiltered air.